In the normal operation process of diesel generator set, from the selection of the unit to the installation of the diesel generator set, to the selection of oil, antifreeze and fuel oil of the diesel generator set, the service life of the diesel generator set is completely different. A normal diesel car is basically no problem to drive for ten years, and a diesel generator set is rarely driven for ten years, In essence, both of them are diesel engines that output power when the main body of the diesel engine goes out and the diesel runs out. The diesel generator set uses the diesel engine of power, which is well-known in the engine industry in China; Famous for its good quality;

柴油發電機組在正常停機的狀況下如下操作：

The diesel generator set operates as follows under the condition of normal shutdown:

1）逐步降低發電機組的運用負載、斷開柴油發電機組的負載開關，將轉換開關轉動至手動位置；

1) Gradually reduce the operating load of the generator set, disconnect the load switch of the diesel generator set, and turn the transfer switch to the manual position;

2）空載下調轉速降至600-800轉/分，空車運轉數分鐘后再推進油泵手柄中止供油，待停機后將手柄復位；

2) Reduce the speed to 600-800 RPM under no load, and then push the handle of the oil pump to stop oil supply after running empty for several minutes, and reset the handle after shutdown;

3）當環境溫度小于5℃時，應將水泵及柴油機的冷卻水全部放盡；

3) When the ambient temperature is less than 5 ℃, the cooling water of the water pump and diesel engine should be drained completely;

4）調速手柄放到轉速低位置，電壓開關放到手動位置；

4) Put the speed control handle to the low speed position and the voltage switch to the manual position;

5）短期停車可不關燃油開關，避免空氣進入燃油桶，長期停車應在停車后打開燃油開關；

5) For short-term shutdown, the fuel switch can not be turned off to prevent air from entering the fuel barrel. For long-term shutdown, the fuel switch should be turned on after the shutdown;

6）長期停車的話放盡機油；

6) Drain the engine oil if parking for a long time;

二、柴油發電機組緊急停車

2、 Emergency shutdown of diesel generator set

當發電機組呈現下列狀況時，緊急停機。此時應先切斷負載，并立刻將噴油泵開關轉到切斷油路的位置，致使柴油機立刻停機；

When the generator set presents the following conditions, it will be shut down in an emergency. At this time, cut off the load first, and immediately turn the fuel injection pump switch to the position of cutting off the oil circuit, so that the diesel engine will stop immediately;

1）柴油發電機組冷卻水箱溫度超越99℃；

1) The temperature of cooling water tank of diesel generator set exceeds 99 ℃;

2）機組發作猛烈的敲擊聲，或者有冷部件損壞；

2) The unit has violent knocking sound, or cold parts are damaged;

3）氣缸、活塞、調速器等運動部件卡死；

3) Cylinder, piston, governor and other moving parts are stuck;

4）發電機電壓超越表中大讀數時；

4) When the generator voltage exceeds the large reading in the meter;

5）發作火災或漏電及其他自然災禍時；

5) Fire or electricity leakage and other natural disasters;

柴油發電機組呈現異常狀況時，一時間排查切勿再呈現問題停機之后，沒排查到事故發作緣由二次啟動機器；容易形成發電機組的二次損壞；

When the diesel generator set shows abnormal conditions, check for a time and do not show problems again. After shutdown, the machine is started again without checking the cause of the accident; It is easy to cause secondary damage to the generator set;

以上就是為大家介紹的有關天然氣發電機組的詳細的介紹,希望對您有所幫助.如果您有什么疑問的話,歡迎聯系我們.我們將以專業的態度,為您提供服務http://www.hfdxyy.com

The above is a detailed introduction about natural gas generator set, which I hope will be helpful to you If you have any questions, please contact us We will provide you with professional service http://www.hfdxyy.com